Product ID:H.S.BAKING GLOSS ENAMEL NON-LEAD COLORS (SU
MSDS Date:12/29/1986
FSC:8010
NIIN:00N035035
MSDS Number: BQCCM

SHERWIN-WILLIAMS CO

101 PROSPECT AVE NW
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

CHILDREN. COATING CONTAINS MATLS CLASSIFIED AS

RTECS: 9999999ZZ

CALCIUM CARBONATE, ETC, WHICH MAY BE PRESENT AT HAZ

RTECS: 9999999ZZ

APPLICABLE EXPOSURE LIMITS. REFER TO OSHA STANDARDS

RTECS: 9999999ZZ

5.9

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <5%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLVENT NAPHTHA (PETROLEUM) LIGHT AROMATIC; (LIGHT AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 5%

ACGIH TLV: 100 PPM (MFR)

33

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <5%

OSHA PEL 400 PPM;500 PPM STEL

ACGIH TLV: 400 PPM;500 PPM STEL

5.5

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

8.7

CAS: 78-83-1

RTECS: NP9625000

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

760

CAS: 50-00-0

RTECS: LP8925000

Fraction By Weight: <0.5%

OSHA PEL SEE 1910.1048

ACGIH TLV: C 0.3 PPM; A2; 9293

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III).

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10-25%

OSHA PEL 150 PPM;200 PPM STEL

ACGIH TLV: 150 PPM;200 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: <5%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-35%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

REPORTS HAVE ASSOC RPTD & PRLNG OVEREXP TO

RTECS: 9999999ZZ

BY DELIBERATELY CONCENTRATING & INHALING CONTENTS

RTECS: 9999999ZZ

OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING

RTECS: 9999999ZZ

TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:OVEREXP CAUSES EYE, SKIN & RESP
IRRIT. MAY CAUSE NERV SYS DEPRESS ACCOMPANINED BY HDCH, DIZZ, NAUS,
CONFUSN & STAG GAIT. EXTREME OVEREXP MAY RSLT IN UNCON & POSS
DEATH. MAY CAUSE ALLERGIC RESP & /OR SKIN RXN IN SUSCEPTIBLE
PERSONS. CHRONIC:EXPOS TO HIGH LEVELS OF FORMALDEHYDE HAS BEEN
SHOWN TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:ANTICIPATED TO BE A
CARCINOGEN (NTP); GROUP 2A (IARC); OSHA REGULATED.
Effects of Overexposure:HLTH HAZ:CAUSE CANCER OF NASAL CAVITY IN RATS.
AVAIL EVID IN HUMANS IS INCONCLUSIVE. PRLNG OVEREXP TO INGS MAY
CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD FORMING & REPRO SYS.
RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG
CANCER, HOWEVER SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE.
(ING 10)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER
BEFORE RE -USE. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:81.0F,27.2C
Lower Limits:0.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZLES ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. PROT AGAINST DUST WHICH MAY
BE GEN BY SANDING/ABRADING DRIED FILM.
Other Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA VENTED; DO
NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS; TURN OFF
STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES(ING 12)

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR NIOSH/MSHA APPROVED
RESPIRATORY DEVICE FOR PROTECTION AGAINST MATERIALS IN INGREDIENTS
SECTION.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIAL IN INGREDIENTS IS MAINTAINED BELOW (ING 16)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:USE OF BARRIER CREAM ON EXPOSED SKIN IS
RECOMMENDED.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:BLENDING CLEAR, F73 V 700. FIRE FIGHT
PROC:CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. EXPLO HAZ:SURFS REQS SPECIAL PRECS. DURING
EMER C NDTNS OVEREXP TO DECOMP PRODS MAY CAUSEHLTH HAZ. SYMPS MAY
NOT BE IMMED APPARENT. OBTAIN MED ATTN.

HCC:F4
Boiling Pt:B.P. Text:>178F,>81C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.04-1.41
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:33

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF NITROGEN.

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC
EPA HAZ WASTE NUMBERS. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD
CNTNRS. DISP OF I /A/W FED, STATE & LOC REGS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.